Hasil Pencarian  ::  Simpan CSV :: Kembali

Hasil Pencarian

Ditemukan 166100 dokumen yang sesuai dengan query
cover
"This study was carried out with the main purpose to investigate the grafting of methacrylic acid (MAA) on silica extracted from rice husk and to test the capability of the grafted silica to adsorb CU2+ from aqueous media....."
SIGMAAB
Artikel Jurnal  Universitas Indonesia Library
cover
Burmawi
"The synthesis of silica from rice husk ash has been studied. The purification has been done by adding acid solution and by heating. The sample heated in the temperature range of 700 - 1000°C. The characterization was done by means of the X- Ray diffraction, Electron microscope and X-ray Fluorescence. The results show the RHA after burning contain 59.72 % wt, after heating the weight fraction of silica increase, 700°C around 84.59%, 850°C around 85.75 % and 1000°C around 87.55 %. Electron microscope shows the evolution of microstructure on heating. From the evolution of impurity elemens in the RHA, it is concluded that the increased of silica contained is due to decrease of potassium contain in the RHA."
Depok: Fakultas Matematika dan Ilmu Pengetahuan Alam Universitas Indonesia, 2008
T29082
UI - Tesis Open  Universitas Indonesia Library
cover
Achmad Fauzi Trinanda
"Penelitian ini dilakukan untuk mengetahui kemampuan dari abu sekam padi (RHA) sebagai sumber silika untuk larutan aktivator geopolimer berbahan baku metakaolin. Pada penelitian ini digunakan dua jenis abu sekam padi dengan komposisi silika yang tidak jauh berbeda, tetapi memiliki sifat kristalinitas yang berbeda. Abu sekam padi dilarutkan menggunakan larutan KOH dengan konsentrasi sebesar 8 M selama 4, 8 dan 24 jam. Hasil pelarutan optimum dicapai setelah proses pelarutan selama 24 jam untuk kedua jenis abu sekam padi. Besar persen massa terlarut dari kedua jenis abu sekam padi menunjukkan hasil yang berbeda. Abu sekam padi dengan sifat yang lebih amorf memiliki kelarutan yang lebih tinggi dengan pengurangan massa sebesar 80,4 % dan penurunan kadar silika hingga 32,04 %. Larutan dengan kelarutan paling optimum kemudian digunakan sebagai aktivator geopolimer berbahan dasar metakaolin (Metastar®) dengan variasi perbandingan antara metakaolin dan larutan sebesar 60:40, 60:60 dan 40:60 dan digeopolimerisasi pada suhu 60 OC selama 24 jam. Hasil uji tekan menunjukkan kekuatan optimum didapatkan pada komposisi antara metakaolin dan larutan aktivator sebesar 40:60 dengan kekuatan rata-rata sebesar 11,38 MPa.

This research assesses the feasibility of rice husk ash (RHA) as raw materials for the production of metakaolin-based geopolymer pastes. Two kinds of RHA were used in this research with a bit different of composition in silica, but have different cristallinity. At the beginning, the RHA samples were being dissolved into KOH with concentration of 8M for 4, 8 and 24 hours. The optimum solubility of RHA samples was reached after being dissolved in 24 hours for both RHAs. However, the dissolved mass percentage of these RHA shows different results. Amorphous RHA has higher dissolved mass of 80,4 % and reduction of silica composition up to 32.04%. Then, the solution with optimum solubility being used as activator for metakaolin-based geopolymer pastes with three variations of metakaolin to solution ratio of 60:40, 50:50 and 40:60 and being cured in 60 OC for 24 hours. The result shows optimum compressive strength was reached by metakaolin to solution ratio of 40:60 with average compressive strength of 11,38 MPa."
Depok: Fakultas Teknik Universitas Indonesia, 2019
S-Pdf
UI - Skripsi Membership  Universitas Indonesia Library
cover
Palupi, Dian
"Limbah sekam padi mengandung selulosa dengan jumlah yang besar yaitu sekitar 50%. Asam levulinat merupakan platform chemical berbagai industri kimia yang dapat diperoleh dari reaksi dehidrasi selulosa yang merupakan hasil hidrolisis dari selulosa. Dalam penelitian Chen (2011), Mn/ZSM-5 merupakan katalis heterogen yang dapat meningkatkan % yield asam levulinat yang terbentuk dalam sistem reaksi mirip Fenton. Selulosa dari limbah sekam padi ini dapat diisolasi melalui proses pretreatment, yaitu dewax dan delignifikasi. Penggunaan NaOH 10% masih menghasilkan kandungan lignin yang tinggi sehingga dibutuhkan proses delignifikasi lanjutan menggunakan NaOCl.
Hasil dari proses pretreatment kemudian dihidrolisis dengan H3PO4 20%, 30%, dan 40% dengan dikatalisis oleh Mn/ZSM-5 mesopori. Diperoleh asam levulinat pada variasi konsentrasi H2O2 30% dengan konsentrasi asam levulinat 11,9585 mg/L. Sekam padi yang didelignifikasi lebih lanjut dengan NaOCl menghasilkan selulosa dengan karakter Iα dan Iβ. Tidak diperoleh asam levulinat dari hasil reaksi konversi selulosa dari sekam padi yang didelignifikasi dengan NaOCl dengan konsentrasi H3PO4 40%. Dan diperoleh asam levulinat pada reaksi konversi selulosa dari limbah sekam padi yang didelignifikasi dengan NaOH.

Rice husk waste contains high number of cellulose, it’s about 50%. Levulinic acid is a platform chemical a variety of chemical industry that can be obtained from dehydration reaction of cellulose that is a hydrolysis product of cellulose. On the research of Chen (2011), Mn/ZSM-5 is a heterogeneous catalyst that can increase the % yield levulinic acid formed in the reaction system similar Fenton. Cellulose from rice husk waste can be isolated through pretreatment process, which dewax and delignification. The use of NaOH 10% still produces high number of lignins, so continued delignification is needed and the use of NaOCl is suggested.
The results of the pretreatment process then hydrolyzed with H3PO4 20%, 30%, and 40% which is catalyzed by mesoporous Mn/ZSM-5. Levulinic acid is produced with concentration of 11,9585 mg/L at the concentration of H2O2 is 30%. Rice husks which is delignified with NaOCl produces cellulose Iα and Iβ. Levulinic acid isn’t produced from the reaction of cellulose conversion from rice husks which is delignified with NaOCl and concentration of H3PO4 is 40%. And levulinic acid was formed on the reaction of cellulose conversion in which the cellulose obtained by deliginifying the rice husks with NaOH.
"
Depok: Fakultas Matematika dan Ilmu Pengetahuan Alam Universitas Indonesia, 2014
S57438
UI - Skripsi Membership  Universitas Indonesia Library
cover
Ahmad Maksum
Depok: Fakultas Teknik Universitas Indonesia, 2011
T30230
UI - Tesis Open  Universitas Indonesia Library
cover
Muhammad Azka Fariky
"Komoditas utama di sektor pertanian Indonesia adalah padi, yang juga merupakan tanaman pokok di negeri ini sehingga limbah yang dihasilkan juga akan sangat banyak. Untuk mengatasi hal seperti ini, maka pengolahan limbah sekam padi kerap dilakukan. Sekam padi mengandung 50% selulosa, 25 ?30 % lignin, dan 15 ?20 % silika. Kandungan silika ini yang nantinya akan berharga setelah diolah lebih lanjut, setelah dilakukan pemanggangan sempurna sekam padi mengandung sekitar 90%-98% silika.
Pada penelitian ini pengolahan sekam padi dilakukan dengan metode pelindian pada larutan HCl 1 M selama 3 jam, kemudian di recovery dan dilanjutkan pemanggangan dengan variasi laju temperaturnya 3C/min., 5C/min., dan 7C/min. hingga 650C dan ditahan selama 4 jam. Hasil penelitian didapatkan dengan variasi laju temperaturnya 3C/min., 5C/min., dan 7C/min silika dengan kadar 99,170%, 99,038%, dan 98,966%. Proses pelindian dan pemanggangan akan menghilangkan komponen-komponen organik dan logam pengotor-pengotor di dalamnya, dan apabila diamati morfologinya, sekam padi yang telah diberi perlakuan strukturnya akan lebih halus dan berporos.

The main commodities in the agricultural sector of Indonesia is rice, which is also a staple crop in this country so that the waste generated will also be very much. To cope with this kind of thing, then the rice husk waste treatment is often done. Rice husks contain 50% cellulose, 25% lignin -30 and 15 -20% silica. The silica content of which will be valuable when processed further, after perfect roasting rice husk contains about 90% -98% silica.
In this study, rice husk processing is done by the method of leaching in 1 M HCl solution for 3 hours, then recovered and continued roasting by the temperature rate variation of 30C/min., 50C/min., and 70C/min until reaching 6500C and held for 4 h. Research results obtained by varying the temperature rate of 30C/min., 50C/min., and 70C/min with silica content of 99.170%, 99.038% and 98.966%. Leaching and roasting process will eliminate the components of organic and metallic impurities in it, and if the morphology was observed, rice husk which has been treated to be more delicate and highly porous structure.
"
Depok: Fakultas Teknik Universitas Indonesia, 2016
S62829
UI - Skripsi Membership  Universitas Indonesia Library
cover
F.X. Eko Arianto
"Potensi biomassa di Indonesia sangat melimpah baik dari limbah hewan maupun tumbuhan. Limbah pertanian dan perkebunan yang cukup besar dapat dimanfaatkan sebagai sumber energi. Salah satunya adalah sekam padi. Pada eksperimen ini pemanfaatan energi dari sekam padi dilakukan dengan metode gasifikasi menggunakan downdraft gasifier untuk mengubahnya menjadi gas-gas mampu bakar yang selanjutnya akan dibakar pada cyclone combustor. Keuntungan menggunakan metode gasifikasi dibandingkan pembakaran langsung adalah pembakaran lebih bersih, partikulat dan kontaminan dapat dihilangkan sebelum dibakar. Cyclone combustor dapat menghasilkan pencampuran yang baik sehingga cocok digunakan untuk gas dengan nilai kalor rendah.
Komposisi syngas yang dihasilkan dari gasifikasi sekam padi adalah H2 13,6%, CO 14,9%, CO2 12,9% dan CH4 2,3% [1]. Setelah melewati cyclone separator untuk menghilangkan uap air dan kontaminan kemudian masuk ke storage tank yang selanjutnya masuk ke dalam cyclone combustor untuk dibakar setelah dicampur dengan udara melalui inlet yang berbeda. Kemudian akan divariasikan dengan berbagai AFR untuk mengetahui perubahan temperatur api, letak api pada combustor dan bentuk apinya. Dari hasil eksperimen pada AFR = 1,59 terletak di dalam combustor pada daerah antara plane 1 dan 2, AFR = 1,14 api terletak di dalam pada plane 2, AFR = 0,69 api terletak di dalam pada plane 3 sedangkan pada AFR = 0,27 tidak terbentuk api di dalam tetapi di luar setelah bercampur dengan udara luar.

Biomass potential in Indonesia is very abundance whether from animal or plant waste. Farming and plantation waste that abundance enough can be utilized as energy sources. One of them is rice husk. On this experiment energy utilization of rice husk was used gasification method with downdraft gasifier to convert it to combustible gases which would be burn in a cyclone combustor. The advantages of gasification method compare to direct combustion are cleaner combustion and particulates and contaminants can be eliminated prior to burn. Cyclone combustor can generate a good mixing then suitable to use for gases with low calorific value.
Composition of syngas that produced by gasification of rice husk are H2 13,6%, CO 14,9%, CO2 12,9% dan CH4 2,3% [1]. After syngas leaves the reactor it enter cyclone separator to eliminate water vapor and contaminants and then goes to the storage tank and finally goes to cyclone combustor to be burned after mixed with air through different inlet. After that different value of AFR would be varied to see the change of flame temperature, flame postion in combustor and flame shape. Kemudian akan divariasikan dengan berbagai AFR untuk mengetahui perubahan temperatur api, letak api pada combustor dan bentuk apinya. From the result of eksperimen at AFR = 1.59 the flame in the combustor beetween plane 1 and 2, at AFR = 1.14 the flame in the combustor at plane 2, at AFR = 0.69 the flame in the combustor beetween plane 3 and at AFR = 0.27 the flame on the outside of the combustor after mixed with fresh air.
"
Depok: Fakultas Teknik Universitas Indonesia, 2016
T46556
UI - Tesis Membership  Universitas Indonesia Library
cover
Panggih Dwi Raharjo
"ABSTRAK
Indonesia merupakan negara agraris yang merupakan produsen padi ketiga di dunia setelah Cina dan India. Hal ini menyebabkan banyaknya sekam padi yang terbuang menjadi limbah. Di dalam sekam padi ini terdapat ~20% silika yang dapat diberdayakan. Silika dalam sekam padi ini dapat diekstraksi dengan melakukan proses pelindian menggunakan larutan asam klorida 1 M, dengan variasi waktu pelindian 30, 75, dan 120 menit, yang kemudian dilanjutkan dengan pembakaran hingga suhu 650°C dengan kecepatan peningkatan suhu 5°C/menit. Hasil akhir kemudian dikarakterisasi kadar dan morfologinya. Hasil penelitian didapatkan bahwa kadar akhir silika yang didapatkan dengan pelindian selama 30, 75 dan 120 menit masing-masing sebesar 98,282%, 99,323%, dan 99,429%, Sekam padi hasil ekstraksi mengalami perubahan morfologi menjadi lebih halus dengan penambahan waktu pelindian.
ABSTRACT
Indonesia is an agricultural country that produces rice number three in the world, after China and India. It makes there are bulk of rice husks that goes to waste. Rice husks contain approximately 20% of silica that can be empowered. Silica from rice husks can be extracted through leaching method using chloric acid 1 M, with time variate from 30, 75, and 120 minutes, and then continued with combustions until temperature 650°C with rate of 5°C/minutes. The results from this study then characterized and achieved the final concentration of silica for leaching time 30, 75 and 120 minutes is 98.282%, 99.323%, and 99.429%. The final sample encountered a morphology change to become smoother as the leaching time increase."
Fakultas Teknik Universitas Indonesia, 2016
S62719
UI - Skripsi Membership  Universitas Indonesia Library
cover
Dessy Prawesti Kusumawardhani
"Penelitian ini sendiri dilakukan dengan membakar sekam padi pada temperatur 700oC sampai berubah menjadi abu sekam padi. Selanjutnya, abu sekam padi diberikan perlakuan mekanokimia ayng bertujuan untuk mengurangi ukuran partikel. Proses mekanokimia menggabungkan proses mekanik dengan menggunakan planetary ball mill dan proses kimia dengan menambahkan asam klorida 1M. Pada penelitian ini proses mekanokimia dilakukan selama 15 menit dan 30 menit sebagai variasi. Langkah selanjutnya yaitu menambahkan abu sekam padi hasil proses mekanokimia tersebut ke dalam beton sebagai material pengganti semen. Beton dibuat menggunakan cetakan 10 cm x 10 cm dan uji tekan beton akan dilakukan setalah curing selama 28 hari. Beton dengan abu sekam padi hasil proses mekanokimia 30 menit mempunyai kekuatan tekan sebesar 15,15 MPa dan beton dengan abu sekam padi hasil proses mekanokimia 15 menit mempunyai kekuatan tekan sebesar 14,8 MPa.

This research was carried out by burning the rice husk at 700oC until it turned into grayish white ash. After that, rice husk ash was given a mechano-chemical treatment to reduce the partikel size. Mechano-chemical process combines the mechanical process using planetary ball mill and chemical process by adding the hydrochloric acid 1M. In this research, mechano-chemical process was conducted for 15 minutes and 30 minutes as variation. Next step was used the rice husk ash from mechano-chemical process as cement replacement. Concrete was made on 10 cm x 10 cm mold and compressive test will was carried out after 28 days of curing process. The compressive strength of concrete with the addition of rice husk ash from mechano-chemical process is 15,15 MPa and the compressive strength of concrete with the addition of rice husk ash from mechano-chemical process is 14,8 MPa.
"
Depok: Fakultas Teknik Universitas Indonesia, 2019
S-pdf
UI - Skripsi Membership  Universitas Indonesia Library
cover
Situmorang, Frans Wensten
"Sekam padi merupakan limbah pertanian yang sangat banyak jumlahnya di negara penghasil beras. Pada tahun 2015, Indonesia sebagai negara penghasil beras memproduksi padi sebanyak 75 juta ton dan sekitar 20-25 dari berat total padi adalah sekam padi. Akumulasi dari limbah sekam padi yang sangat banyak ini dapat menjadi ancaman bagi lingkungan. Salah satu cara untuk mengurangi akumulasi dari limbah tersebut ialah dengan memanfaatkan limbah tersebut. Sekam padi mengandung silika dengan nilai sekitar 20-25 dari berat total sekam padi. Silika memiliki banyak aplikasi dalam industri gelas, keramik, dan semen.
Pada penelitian ini silika diesktraksi dari abu sekam padi menggunakan metode alkali yang disertai dengan proses refluks. Abu sekam padi direfluks menggunakan larutan NaOH dengan konsentrasi 5, dan 10 selama 1 jam pada temperatur 80 C. Proses ini menghasilkan larutan Sodium Silikat Na2SiO3. Selanjutnya, asam HCl atau CH3COOH ditambahkan secara perlahan ke dalam larutan sodium silikat disertai dengan pengadukan dengan kecepatan konstan. Proses ini akan menghasilkan silika gel. Silika gel yang terbentuk diisolasi pada temperatur 30 C selama 18 jam. Selanjutnya, silika gel dipanaskan selama 12 jam dengan temperatur 120 C. Proses ini akan menghasilkan xerogel. Xerogel kemudian dikarakterisasi. Metode karakterisasi material yang digunakan ialah X-ray Diffraction XRD, Fourier transform infrared FTIR, Braun Emmet Teller BET, dan Energy Dispersive X-Ray EDX. Hasil penelitian menunjukkan bahwa silika yang diekstraksi dari sekam padi banyak mengandung unsur Si dan O.
Berdasarkan hasil analisis XRD, silika yang dihasilkan dari sekam padi merupakan silika amorf, dan berdasarkan hasil analisis FT-IR, terdapat vibrasi tekuk dan ulur Si-O dalam serbuk silika. Silika dengan pengasaman menggunakan asam HCl memiliki luas permukaan sebesar 236,2 m2/g. Sementara silika dengan pengasaman menggunakan asam CH3COOH memiliki luas permukaan sebesar 204,8 m2/g. Silika yang diasamkan dengan HCl memiliki yield tertinggi yaitu sebesar 74,9 yang didapatkan dari rasio antara 3,745 gr massa xerogel dengan 5 gr massa abu sekam padi. Silika yang diasamkan dengan CH3COOH memiliki yield terendah yaitu sebesar 60,06 yang didapatkan dari rasio antara 3,003 gr massa xerogel dengan 5 gr massa abu sekam padi.

Rice Husk RH is an enormous agricultural waste in rice producing country. In 2015, Indonesia, a rice producing country, produced paddy about 75 million tons, and about 20 22 of total weight of paddy is rice husk. The accumulations of these huge amount of rice husk waste can be environmental threat. One of the solution to reduce these accumulations is to utilize these wastes. Rice husk contains silica in the range of 20 ndash 25 wt. Silica has many applications in the glass, ceramics, and cement industries.
In this study, silica was extracted from rice husk using alkaline extraction method with reflux process and it was followed by acidification. In this study, rice husks ash RHA was refluxed by aqueous NaOH with concentration 5 and 10, for 1 hour at 80 C. This process produced Sodium Silicate solution Na2SiO3. Next, HCl or CH3COOH acid was added dropwise into the sodium silicate solution under constant stirring condition until pH 7. This process produced wet gel silica. The silica gel obtained was isolated at 30 C for 18 hours. Then, it was heated to 120 C for 12 hours to produce xerogel. Next, xerogel was characterized. The Characterization methods which were used in this study are X ray Diffraction XRD, Fourier transform infrared FTIR , Braun Emmet Teller BET, and Energy Dispersive X Ray EDX. The results showed that silica which was extracted from rice husks contains many Si and O elements.
Based on XRD analysis, silica produced from rice husk ash is an amorphous silica and based on FT IR analysis, it has bending and stretching vibration of Si O. Silica with HCl acidification has a surface area 236.2 m2 g. In the other hand, silica with CH3COOH acidification has a surface area 204.8 m2 g. Silica which acidified by HCl has the highest yield, that is about 74.9 which was obtained from ratio between 3.745 gr mass of xerogel and 5 gr mass of RHA. Silica which acidified by CH3COOH has the lowest yield, that is about 60.06 which was obtained from ratio between 3.003 gr mass of xerogel and 5 gr mass of RHA. Keywords Rice husk ash Silica Alkaline extraction Reflux process Xerogel.
"
Depok: Fakultas Teknik Universitas Indonesia, 2018
S-Pdf
UI - Skripsi Membership  Universitas Indonesia Library
<<   1 2 3 4 5 6 7 8 9 10   >>