ABSTRAK Geopolimer telah mendapat perhatian yang sangat besar sebagai teknologi hijaudalam material kontruksi khususnya beton dan alternatif pengganti semen. Salahsatu pengembangan teknologi geopolimer saat ini adalah geopolimer berbahanabu terbang. Proses sintesis geopolimer berbahan abu terbang dalam penelitian inidilakukan pada konsentrasi larutan NaOH 6,5M, 8,6M, 10,5M dan 12.5M denganpenggantian sebagian kecil abu terbang yaitu 0%, 5%, 10% dan 15% padatermperatur curing 600C selama 24 jam. Hasil investigasi menunjukkan bahwasemakin besarnya konsentrasi larutan NaOH maka semakin besar sifat mekanikyang dihasilkan yaitu kekuatan tekan (compresive strength) 60,3MPa (12,5M) dankekuatan lentur (flexural strength) 16MPa (10,5M), namun semakin tingginyakosentrasi larutan NaOH juga menyebabkan terbentuknya karbonasi pada pastageopolimer. Disamping itu, penggantian silica fume diharapkan memberikankekuatan lebih tinggi pada pasta geopolimer berdasarkan rasio Si/Al ternyata tidaksesuai yang diinginkan, kekuatan tekan turun dengan penambahan silica fume.Namun demikian, semakin tingginya kosentrasi larutan NaOH membuat kekuatantekan pada penggantian silica fume sebesar 5% pada kosentrasi larutan NaOH 12,5M meningkat menjadi 58,9 MPa. Abstract Geopolymers have attracted extensive attention as a green technology inconstruction materials, especially concrete and cement alternative. One of thecurrent development in geopolymer technology is geopolymers made from flyash. In this study, synthesis of geopolymer have been performed at concentrationof 6,5 M NaOH, 8,6 M, 10,5 M and 12,5M by the replacement of fly ash fractionis 0%, 5%, 10% and 15% with silica fume at 60oC curing temperature for 24hours. The result of investigation showed that the compressive strength 60,3 MPa(12,5M) and flexural strength 16 MPa (10,5M), but the higher concentration ofNaOH causes formation of carbonated in geopolymer paste. In addition, thereplacement of silica fume is expected to provide higher strength geopolymerpastes based on the ratio of Si/Al was not desired, the compressive strengthdecreased with addition of silica fume. However, the higher concentration ofNaOH by the replacement of fly ash fraction 5% with silica fume, increased to58,9 MPa at concentration of 12, 5M NaOH. |